Quickload for Hammer 118 HHT 7x57 25" bbl
- Thread starter preacher
- Start date
hunter24605
Handloader
- Apr 30, 2016
- 2,385
- 3,669
Not quick load but from Hammer bullets
| 7x57mm Mauser | Barrel Length 24" | Case 2.244" | ||||
| †113 Shock Hammer | Twist Rate or Faster 1-12.5" | C.O.A.L. *2.720" | ||||
| 120 Hammer Hunter | Twist Rate or Faster 1-10.5" | C.O.A.L. *2.945" | ||||
| Powder | Start Charge | Fill % | Start F.P.S. | Velocity at Max | ||
| Accu 2495 | 39 | 82 | 2700 | 2950 | ||
| Alli RL 15 | 41 | 83 | 2800 | 2950 | ||
| Hodg CFE-223 | 47 | 90 | 3050 | 3300 | ||
| Hodg H4350 | 45 | 86 | 2800 | 3000 | ||
| IMR 4064 | 39 | 79 | 2700 | 2850 | ||
| Ramshot Big Game | 44 | 85 | 2700 | 2900 | ||
| Viht N150 | 42 | 89 | 2800 | 3100 | ||
| Viht N540 | 41 | 82 | 2700 | 2950 | ||
| Win 748 | 40 | 78 | 2750 | 2900 | ||
| Win StaBall 6.5 | 49 | 93 | 2850 | 3150 | ||
| Win 760 | 48 | 93 | 3000 | 3200 |
DrMike
Ballistician
- Nov 8, 2006
- 36,923
- 5,112
If I accept the SAAMI limit of 51K psi, A2495 gives this value:
If I up the maximum chamber pressure to 64K psi, the projection is:
Code:
Cartridge : 7 x 57 mm Mauser (SAAMI)
Bullet : .284, 120, Hammer HH
Useable Case Capaci: 54.234 grain H2O = 3.521 cm³
Cartridge O.A.L. L6: 3.071 inch = 78.00 mm
Barrel Length : 25.0 inch = 635.0 mm
Powder : Accurate 2495
Predicted data by increasing and decreasing the given charge,
incremented in steps of 1.0% of nominal charge.
CAUTION: Figures exceed maximum and minimum recommended loads !
Step Fill. Charge Vel. Energy Pmax Pmuz Prop.Burnt B_Time
% % Grains fps ft.lbs psi psi % ms
-10.0 81 39.69 2747 2011 36121 7781 100.0 1.402
-09.0 82 40.13 2775 2052 37329 7822 100.0 1.381
-08.0 83 40.57 2803 2093 38574 7861 100.0 1.360
-07.0 84 41.01 2830 2134 39856 7900 100.0 1.339
-06.0 85 41.45 2857 2176 41176 7938 100.0 1.319
-05.0 86 41.90 2885 2217 42536 7975 100.0 1.299
-04.0 87 42.34 2911 2258 43937 8012 100.0 1.280 ! Near Maximum !
-03.0 87 42.78 2938 2300 45380 8049 100.0 1.261 ! Near Maximum !
-02.0 88 43.22 2964 2342 46867 8085 100.0 1.243 ! Near Maximum !
-01.0 89 43.66 2991 2383 48399 8121 100.0 1.225 ! Near Maximum !
+00.0 90 44.10 3017 2425 49978 8156 100.0 1.207 ! Near Maximum !
+01.0 91 44.54 3043 2467 51605 8191 100.0 1.190 !DANGEROUS LOAD-DO NOT USE!
+02.0 92 44.98 3069 2509 53283 8225 100.0 1.173 !DANGEROUS LOAD-DO NOT USE!
+03.0 93 45.42 3095 2552 55011 8259 100.0 1.156 !DANGEROUS LOAD-DO NOT USE!
+04.0 94 45.86 3120 2594 56794 8292 100.0 1.140 !DANGEROUS LOAD-DO NOT USE!
+05.0 95 46.31 3146 2637 58632 8324 100.0 1.124 !DANGEROUS LOAD-DO NOT USE!
Results caused by ± 5% powder lot-to-lot burning rate variation using nominal charge
Data for burning rate increased by 5% relative to nominal value:
+Ba 90 44.10 3075 2519 55537 7980 100.0 1.154 !DANGEROUS LOAD-DO NOT USE!
Data for burning rate decreased by 5% relative to nominal value:
-Ba 90 44.10 2945 2310 44459 8371 100.0 1.271 ! Near Maximum !If I up the maximum chamber pressure to 64K psi, the projection is:
Code:
Cartridge : 7 x 57 mm Mauser (SAAMI)
Bullet : .284, 120, Hammer HH
Useable Case Capaci: 54.234 grain H2O = 3.521 cm³
Cartridge O.A.L. L6: 3.071 inch = 78.00 mm
Barrel Length : 25.0 inch = 635.0 mm
Powder : Accurate 2495
Predicted data by increasing and decreasing the given charge,
incremented in steps of 1.0% of nominal charge.
CAUTION: Figures exceed maximum and minimum recommended loads !
Step Fill. Charge Vel. Energy Pmax Pmuz Prop.Burnt B_Time
% % Grains fps ft.lbs psi psi % ms
-10.0 87 42.48 2920 2272 44404 8024 100.0 1.274
-09.0 88 42.95 2949 2317 45965 8064 100.0 1.254
-08.0 89 43.42 2977 2361 47577 8102 100.0 1.234
-07.0 90 43.90 3005 2406 49242 8140 100.0 1.215
-06.0 91 44.37 3033 2451 50961 8177 100.0 1.197
-05.0 92 44.84 3061 2496 52737 8214 100.0 1.178
-04.0 93 45.31 3088 2541 54571 8250 100.0 1.161 ! Near Maximum !
-03.0 94 45.78 3116 2586 56467 8286 100.0 1.143 ! Near Maximum !
-02.0 95 46.26 3143 2632 58425 8321 100.0 1.126 ! Near Maximum !
-01.0 96 46.73 3170 2678 60449 8355 100.0 1.109 ! Near Maximum !
+00.0 97 47.20 3197 2724 62542 8388 100.0 1.093 ! Near Maximum !
+01.0 97 47.67 3224 2770 64705 8421 100.0 1.077 !DANGEROUS LOAD-DO NOT USE!
+02.0 98 48.14 3251 2816 66943 8453 100.0 1.061 !DANGEROUS LOAD-DO NOT USE!
+03.0 99 48.62 3278 2863 69258 8485 100.0 1.046 !DANGEROUS LOAD-DO NOT USE!
+04.0 100 49.09 3304 2909 71653 8515 100.0 1.031 !DANGEROUS LOAD-DO NOT USE!
+05.0 101 49.56 3331 2956 74132 8545 100.0 1.016 !DANGEROUS LOAD-DO NOT USE!
Results caused by ± 5% powder lot-to-lot burning rate variation using nominal charge
Data for burning rate increased by 5% relative to nominal value:
+Ba 97 47.20 3249 2813 69292 8221 100.0 1.048 !DANGEROUS LOAD-DO NOT USE!
Data for burning rate decreased by 5% relative to nominal value:
-Ba 97 47.20 3133 2616 55802 8591 100.0 1.147 ! Near Maximum !DrMike
Ballistician
- Nov 8, 2006
- 36,923
- 5,112
Knowing you tend to maximize pressures, I've provided the powder projections with a maximum chamber pressure of 64,000 psi.
Code:
Cartridge : 7 x 57 mm Mauser (SAAMI)
Bullet : .284, 120, Hammer HH
Useable Case Capaci: 54.234 grain H2O = 3.521 cm³
Cartridge O.A.L. L6: 3.071 inch = 78.00 mm
Barrel Length : 25.0 inch = 635.0 mm
Predicted Data for Indicated Charges of the Following Powders.
Matching Maximum Pressure: 64000 psi, or 441 MPa
or a maximum loading ratio or filling of 110 %
These calculations refer to your specified settings in QuickLOAD 'Cartridge Dimensions' window.
C A U T I O N : any load listed can result in a powder charge that falls below minimum suggested
loads or exceeds maximum suggested loads as presented in current handloading manuals. Understand
that all of the listed powders can be unsuitable for the given combination of cartridge, bullet
and gun. Actual load order can vary, depending upon lot-to-lot powder and component variations.
USE ONLY FOR COMPARISON !
Powder type Filling/Loading Ratio Charge Charge Vel. Prop.Burnt P max P muzz B_Time
% Grains Gramm fps % psi psi ms
--------------------------------- -----------------------------------------------------------------
ReloadSwiss RS 60 *T 106.7 55.9 3.63 3396 100.0 64000 10149 1.020 ! Near Maximum !
Elcho 17 105.8 55.5 3.60 3377 100.0 64000 10102 1.024 ! Near Maximum !
Alliant Reloder-17 *T 105.8 55.5 3.60 3377 100.0 64000 10102 1.024 ! Near Maximum !
ReloadSwiss RS 70 *C 109.1 58.1 3.77 3367 99.3 64000 10510 1.023 ! Near Maximum !
ReloadSwiss RS 62 109.9 57.6 3.73 3344 99.5 64000 10133 1.039 ! Near Maximum !
PB Clermont PCL 511 107.2 57.1 3.70 3327 98.5 64000 10187 1.033 ! Near Maximum !
Bofors RL16 TZ *C *T 110.0 53.6 3.47 3322 99.6 61757 10034 1.039 ! Near Maximum !
Alliant Reloder-16 *C *T 110.0 53.6 3.47 3322 99.6 61757 10034 1.039 ! Near Maximum !
Winchester 760 104.7 55.4 3.59 3319 97.8 64000 10149 1.036 ! Near Maximum !
Hodgdon H414 104.7 55.4 3.59 3319 97.8 64000 10149 1.036 ! Near Maximum !
Accurate 4350 109.9 55.0 3.56 3315 99.6 64000 9868 1.051 ! Near Maximum !
Vihtavuori N550 *C*T 107.3 54.8 3.55 3314 99.5 64000 10002 1.044 ! Near Maximum !
Hodgdon LVR 107.6 53.8 3.49 3306 99.2 64000 9820 1.036 ! Near Maximum !
Ramshot Hunter 110.0 56.8 3.68 3300 98.3 62333 10124 1.045 ! Near Maximum !
Norma URP *C 110.0 54.4 3.52 3299 99.4 62831 9858 1.047 ! Near Maximum !
Bofors RP19 ~approximation 110.0 54.4 3.52 3298 99.4 62766 9853 1.047 ! Near Maximum !
Norma 204 *C 109.0 56.3 3.65 3275 95.7 64000 9928 1.034 ! Near Maximum !
PB Clermont PCL 518 110.0 56.8 3.68 3274 97.7 60617 10119 1.057 ! Near Maximum !
Bofors RP3 102.7 51.9 3.36 3269 100.0 64000 9246 1.058 ! Near Maximum !
Norma 203 old 102.7 51.9 3.36 3269 100.0 64000 9246 1.058 ! Near Maximum !
Vihtavuori N160 *C 107.0 54.6 3.54 3262 99.4 64000 9324 1.042 ! Near Maximum !
Rottweil R903 105.0 51.9 3.36 3261 100.0 64000 9168 1.058 ! Near Maximum !
Hodgdon H380 101.7 52.0 3.37 3260 99.3 64000 9496 1.052 ! Near Maximum !
Bofors RP4 NT *C ~approximation 110.0 55.8 3.62 3258 97.4 63615 9701 1.047 ! Near Maximum !
Somchem S355 104.8 51.3 3.32 3252 100.0 64000 9169 1.055 ! Near Maximum !
Shooters World SW4350 109.5 54.1 3.51 3251 97.9 64000 9610 1.054 ! Near Maximum !
Lovex S070 109.5 54.1 3.51 3251 97.9 64000 9610 1.054 ! Near Maximum !
Somchem S365 110.0 54.7 3.54 3238 100.0 55837 9570 1.093 ! Near Maximum !
Accurate 4064 103.0 50.4 3.26 3238 100.0 64000 8712 1.077 ! Near Maximum !
Shooters World Match Rifle 97.5 50.2 3.26 3236 100.0 64000 8686 1.062 ! Near Maximum !
Lovex D073.6 97.5 50.2 3.26 3236 100.0 64000 8686 1.062 ! Near Maximum !
Accurate 2520 95.3 50.2 3.26 3236 100.0 64000 8686 1.062 ! Near Maximum !
Lovex S065 108.1 52.9 3.43 3230 98.7 64000 9320 1.055 ! Near Maximum !
Shooters World Long Rifle 108.1 52.9 3.43 3230 98.7 64000 9320 1.055 ! Near Maximum !
SNPE Vectan SP 7 95.9 51.4 3.33 3227 99.2 64000 9149 1.055 ! Near Maximum !
Rottweil R907 106.4 52.2 3.38 3218 97.0 64000 9358 1.052 ! Near Maximum !
Bofors RP7 106.4 52.2 3.38 3218 97.0 64000 9358 1.052 ! Near Maximum !
IMR 4007 SSC 103.0 52.2 3.38 3217 97.0 64000 9350 1.052 ! Near Maximum !
Accurate 2495 97.2 47.5 3.08 3215 100.0 64000 8411 1.082 ! Near Maximum !
Accurate 2460 91.1 49.0 3.18 3200 100.0 64000 8476 1.066 ! Near Maximum !
Lovex D073.5 91.4 49.0 3.18 3200 100.0 64000 8476 1.066 ! Near Maximum !
Rottweil R901 96.7 45.9 2.98 3191 100.0 64000 8359 1.067 ! Near Maximum !
Bofors RP4 ~approximation 110.0 55.0 3.56 3191 94.5 58531 9719 1.075 ! Near Maximum !- Thread starter
- #5
You "know me like a book Doc!" lol I may not get all the way to the top pressure listed, but I can get a whole closer than a stinking 51 psi/cup/whatever! ha/ Thank you, I am thinking that my 25" 7x57 will give me a "stretched string" with this weight out to 350 or so. Last 120's I shot at 3200 was the Nosler BT out of a 24" 6.5x284 Win, pre SAAMI days. It was a sudden killer of deer/antelope! Just couldn't get it to feed right, so...."ain't nobidy gots time fo dat"! 
- Thread starter
- #6
